No.416 Jianye Road, South Jinqiao Area, Pudong, Shanghai, China.
REPLACEMENT OF CEMENT BY FLYASH / BLAST FURNACE SLAG BJAYARAMI REDDY 1 1 Professor and Head Department of Civil Engineering YSR Engineering College of Yogi Vemana University Proddatur YSR Dt - 516 360 AP Abstract In this paper the mix design of structural concrete with partial replacement of cement by flyash /blast furnace slag...
Know Moreslag as an alternative for conventional fine aggregate In this study the compressive strength of mortar and concrete made with partial replacement of fine aggregate using induction fur-nace slag was determined Pertaining to the experimental investigation mixes were prepared with fine aggregates replacement using 20 30 40 50 and 60...
Know Moresteel slag as partial replacement of fine aggregate For this purpose different test on harden concrete were conducted at the age of 28 days like compressive strength on 150 x 150 x 150 mm size cube splitting tensile strength on 150 mm X 300 mm cylinder...
Know Moreconcrete from the results obtained it is found that glass powder can be used as cement replacement material up to particle size less than 75μm to prevent alkali silica reaction Keywords Experimental Investigation Coarse Aggregate Steel Slag Concrete I INTRODUCTION Slag is a partially vitreous by product of the process of smelting ore...
Know MoreThis study aims to evaluate concrete having Waste Marble Powder WMP as partial replacement of cement Marble is the metamorphic form of limestone CaCO 3 and WMP was chosen as substitute of cement on account of its high calcium oxide contentWMP is by-product of marble industry and is an environmental burden...
Know MoreFeb 22 2016 0183 32 Cupola slag was used in concrete as partial replacements for fine and coarse aggregates 5 10 15 20 25 50 and 100 to ascertain applicability in concrete Since the disposal of cupola slag in open area causes environment pollution it can be recycled for use in construction industry without producing any harm to human and environment...
Know MoreThis paper presents the results of investigation on the potentials of cupola slag as a partial replacement option for ordinary Portland cement OPC in applications requiring low permeable concrete The chemical analysis of granulated cupola furnace slag GCFS its fineness bulk density specific gravity and the standard consistency and...
Know MoreSteel slag as partial coarse aggregate replacement and Eco-sand as partial fine aggregate replacement entails economical technical and energy saving benefits To ascertain its technical feasibility to incorporate in concrete production a study on its strength is needed 142 Objective The objective of the present study is...
Know MoreCupola slag was used in concrete as partial replacements for fine and coarse aggregates 5 10 15 20 25 50 and 100 to ascertain applicability in concrete Since the disposal of cupola slag in open area causes environment pollution it can be recycled for use in construction industry without producing any harm to...
Know MoreThe Fly ash granulated slag and silica fume are some of the materials which can be recycled in concrete as partial replacement of cement A number of researches are going on to explore the effect of use of these materials as cement replacements and the results are promising These materials include fly ash silica fume and ground-...
Know Moreconcrete Silica fume is used as a partial replacement for cement by 0 10 and 20 in concrete Copper slag is used as a partial replacement for fine aggregate by 0 10 20 30 40 and 50 Compressive strength split tensile strength and flexural strength are strength parameters studied...
Know MoreIn the current work is to utilize the Cupola furnace slag as partial replacement to coarse aggregates in the concrete mix and to study the effect on strength and durability properties of concrete Keywords Environment Protection Mechanical Properties Cupola Furnace slag Blast furnace slag and Concrete...
Know MoreThis shows that partial replacement of ord inary P ortland cement with cupola furnace slag as new construction material can be utilised f or structural concrete with satis factory strength...
Know MoreMaterials 0 replacement of copper slag 10 replacement of copper slag 20 replacement of copper slag 30 replacement of copper slag Cement 146284 kg 146284 kg 146284 kg 146284 kg Fine aggregate 281715 kg 2535408 kg 225372 kg 1972014 kg Copper slag - 281712 kg 56343 kg 845136 kg Coarse aggregate 20mm 12mm...
Know Moreinproceedings Singh2014UtilizationOC title= Utilization of Cupola Furnace Slag as Partial Replacement to Coarse Aggregate in Concrete Mix author= Mandeep Singh and M Kumar and J Saini year= 2014 table 11 figure 13 figure 21 figure...
Know Moreconcrete GGBS slag is obtained by quenching molten iron slag from a blast furnace in water or steam to produce a glassy granular product that is then dried and ground into a fine powder In this project it is proposed to study the Experimental Behavior of Reinforced Concrete with Partial Replacement of Cement with GGBS...
Know MoreT Ch Madhavi 2014 conducted experiment on Copper Slag In Concrete As Replacement and concluded that Various proportions of copper slag replacement with sand 0 10 20 30 40 50 and partial replacement of fly ash with cement 30 in concrete revealed that the...
Know MoreJan 01 1982 0183 32 The effect of partial replacement of cement by cupola slag on the compressive strength of cement mortar was investigated by varying the slag content from 0 to 40 of a standard cement graded sand 1 275 mix and testing at 7 and 14 days while the water cement slag ratio was kept at 05 throughout...
Know Moregranulated blast furnace slag is better replacement of cement than various other alternativ The rateof strength gain in slag replaced concrete is slow in early stages but with proper curing the strength goes on increasing tremendously The compressive strength decreases when the cement replacement is more than 50 Use of slag or...
Know MoreMay 08 2017 0183 32 This paper discusses the efficiency of using finite-element modelling based on the isothermal calorimetry results for predicting early-age temperature development of in situ concrete In addition this work quantifies the beneficial effect of using ground granulated blast-furnace slag as a partial replacement of cement in structural concrete...
Know MoreGGBS is a by-product of steel manufacturing industries and can also be used as partial replacement to cement...
Know Morepartial replacement of fine aggregate by steel slag on the various strength properties of concrete by using the mix design of M20 grade Test specimen with 0 10 20 30 40 50 of partial replacement of fine aggregate by steel slag were cast and tested for compressive strength after curing period of 7...
Know MoreChart-2 Comparison of percentage change in strength of partial replaced copper slag concrete wrt conventional concrete V CONCLUSION By our Project we conclude that strength of concrete increased by the replacement of M-sand by copper slag saves concrete material cost Here we are using OPC of 53 grade...
Know More- K Bhagat RN Pokar HM Rabadiya Suitability of concrete by using cupola slag as partial replacement of coarse aggregate and foundry sand as partial replacement of Fine aggregate J Eng Technol Innov R 4 3 2017 126- 129...
Know Moreconcrete mix of grade M25 Based on the investigation they Therefore in the present study fly ash and egg shell powder came across the conclusion that water cement ratio of 04 are used in concrete as a partial replacement of cement...
Know Moreconcrete development The present research work deals with a view to develop efficient concrete by addition of steel slag to evaluate the effectiveness of the use of steel slag as a partial replacement in sand To replace Sand with various percentages 10 20 30 40 of steel slag waste in M25 M30 M35 concrete Investigation have...
Know MorematerialWe have used cupola slag aggregate in M20 grade concrete with constant w/c ratio of 05first efforts were made to find optimum percentage of cupola waste with gap of 10 from 0 to 100 percent5 cubes were casted for each mix From that 3 was cured in accelerated concrete curing tank for 3...
Know MoreJ Anne Mary investigated the use of copper slag as partial replacement of fine aggregate and reported that the strength characteristics of copper slag incorporated concrete was found out by replacement of 20 40 60 80 and 100 out of this 40 replacement gives highest compression strength at 28 days more than 3755 higher in...
Know More9 Dr B Krishna Rao Study on Marble Powder as Partial Replacement of Cement in Normal Compacting Concrete 2016 13 01-05 10 Rohit Kumar Er Jitender Dhaka Review on use of marble powder as partial replacement of cement in concrete mix 2016 04 93-97 11...
Know MoreApr 11 2018 0183 32 Chaithra H L1 2015 This paper deals with the effective utilization of waste material in concrete production as a partial replacement for Cement and sand The cement has been replaced by GGBS in the range of 30 40 and 50 by weight of cement quarry sand in the range of 40 50 and 60 by weight of cement for M40 grade mix...
Know More